Wilbur-curtis TCC1N Manuel d'utilisateur télécharger pdf

NSF International requires the following water connection:

1. A quick disconnect or additional coiled tubing (at least 2x the depth of the unit) so that the machine

can be moved for cleaning underneath.

2. Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithapplicable 

federal, state and local codes..

3. Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbesized, 

installed and maintained in accordance with federal, state, and local codes.

Important Safeguards/Symbols

Thisapplianceisdesignedforcommercialuse.Anyservicingotherthancleaningandmaintenance

shouldbeperformedbyanauthorizedWilburCurtisservicetechnician.

 •DoNOTimmersetheunitinwateroranyotherliquid

 •Nevercleanwithscouringpowders,bleachorharshchemicals.

Symbols:

  WARNINGS–Tohelpavoidpersonalinjury  ImportantNotes/Cautions

Sanitation Requirements

Curtis TCCN Units are Factory Pre-Set and Ready to Go… Right From the Box.

Generallytherewillneverbeareasontochangefactorysettings.However,shouldyouneedto

makeslightadjustmentstomeetyourteaneeds,adjustmentinstructionsareprovidedlaterinthis

manual.

System Requirements:

•WaterSource30–90PSI(MinimumFlowRateof1GPM).Ifincomingwatersupplyisgreater

than90PSI,additionalregulationisrequiredtomeettherange.

•Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbe

sized,installedandmaintainedinaccordancewithfederal,state,andlocalcodes.

SETUP STEPS

Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connect

awaterlinefromthewaterltertotheTCCNteadispenser.NOTE:Sometypeofwaterltration

devicemustbeusedtomaintainatrouble-freeoperation.(Inareaswithextremelyhardwater,we

suggestthatasedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyour

systemandenhanceteaquality.

INSTALLATION

1. Remove dispenser from carton.

2.Runawaterlinetotheinletttingbehindthedispenser.Flushthenewwater-

line to remove foreign particles.

3.Connecta¼”aredexibleorcopperwaterlinetothemalettingontheback

of the dispenser.

4.Locatethewatersupplyvalvebehindtheunittoverifypositionisturnedon.

CAUTION:Werecommendedthatthewatersupplyvalve,behindunit,beturnedoffduring

non-business hours.

ModelsIncluded

•TCC1N

•TCC2N

•TCC3N

NOTE:Watersource

pressure must be a

minimumof30PSI

pressure at all times

toinsurethequalityof

the of the product.

5.CleanouttheteaconcentratesystembeforeusingtheTCCNteadispenser.UseaBIB(Bag-

in-Box)stylecleaningsolutiontosimplifythecleaningprocedure.AcleanerlikeBevClean

beveragelinecleanercomesina3gallonbag-in-boxthatconnectsdirectlytoyourbag-in-box

systemforlinecleaning(http://bevclean.com).

a. PlacetheBIBcleanercontainernexttotheTCCNteadispenser.Pullthespout  

from the cleaner box through the marked area. Remove the clear travel cap from

spout.Don’tworryaboutcleanerspillingwhenthecapisremoved.Thespouthas 

an internal seal.

b. From the TCCNteadispenser,pulloutthehosewiththeQCD(bagconnector).

OFF

ISO 9001:2008 REGISTERED

WILBUR CURTIS CO., INC.

6913 West Acco Street

Montebello, CA 90640-5403

For the latest information go to

www.wilburcurtis.com

Tel: 800-421-6150

Fax: 323-837-2410

Service Manual – TCC1/2/3N

Wilbur Curtis Company, inC.

1 2 3 4 5 6 7 8

Résumé du contenu

Page 1 - Wilbur Curtis Company, inC

1NSF International requires the following water connection:1. A quick disconnect or additional coiled tubing (at least 2x the depth of the unit) so t

Page 2 - LOAD PRODUCT

27. Carefullyliftthebagandsetthebagintothedispenser.8. Rest tubing on top of the bag..9. Replacethetopcover.10. Dispensebeveragefr

Page 3 - DAILY CLEANING

3MIXING VALVE ADJUSTMENT:Forcustomerswhowishtoadjusttheavorofthedrink,themixingvalvechangesthewatertoconcentrateratio.Thisvalve

Page 4 - TEA TIPS

46. Allowthedispensertositovernightbeforeushingcleaning solution.7. Flushthesystembyllingaonegalloncontainerwith clean hot water

Page 5 - ExceptWhereNoted

512345678910111213261516171819252423293030222021 1 1A 2 3 4 5 6 7 899A9B1011121314WC-56043WC-5683WC-53116WC-8653WC-38471WC-1906WC-4320W

Page 6 - DOs and DON’Ts

61A29327228279A14289BTCC2N – 2 FAUCETCONFIGURATIONTCC3N – 3 FAUCETCONFIGURATIONILLUSTRATED PARTS LISTTCC2N&TCC3NDOs and DON’TsINSTALLATION1.Do

Page 7 - TROUBLESHOOTING

7TROUBLESHOOTINGSYMPTOMPOSSIBLECAUSESOLUTIONDifcultyprimingtheTCCteadispenser.Adjusting rod on mixing valve is turned in too far.Openuptheva

Page 8 - Product Warranty Information

8ECN 15652 . 2/10/[email protected] . rev DECN 14800 . 2/14/13 @ 14.9 . rev CECN 14129 . 6/7/[email protected] in U.S.A. 2/2014 F-3748 Rev DWILBUR CURTIS CO.,

Modèles reliés TCC3N | TCC2N |

Commentaires sur ces manuels

Pas de commentaire

Wilbur-curtis TCC1N Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Chaudière à eau Wilbur-curtis TCC1N. Wilbur Curtis TCC1N User Manual Manuel d'utilisatio

Résumé du contenu

Modèles reliés TCC3N | TCC2N |

Commentaires sur ces manuels

Produits connexes et manuels pour Chaudière à eau Wilbur-curtis TCC1N